小型制藥凍干機使用注意事項，下面以田楓客戶案例--康希諾采購的0.5平方凍干機（型號TF-SFD-0.5）介紹下：

1. According to the system flow chart to verify that all discharging ports are properly connected to safety area.

請根據系統流程圖和平面布置圖驗證所有的排出口已正確連接，并排放到安全區域。

2.  Utility requirements: make sure that the quality of cooling water conforms to the standard and the compressed air has no moisture.

對公用工程的要求，確保冷卻水的水質符合標準要求，確保壓縮空氣的質量，保證無水份；

3. Please take care to avoid touching the pipelines which temperature may be very high to prevent from being scalded.

有些管道（壓縮機排氣管）溫度會很高，謹防與皮膚接觸，不要被燙傷。

4. Please take care to avoid touching the chamber inside/outside surface due to the high or low temperature to prevent from being scalded

箱體內外部的表面溫度可能會很高或很低，謹防與皮膚接觸。

5. When carrying out the maintenance of the refrigeration system, if it is needed to discharge the refrigerant, please take care not to contact with skins to avoid being frostbiting

當對制冷系統進行檢修時，釋放制冷劑，由于制冷劑溫度很低，謹防與皮膚接觸，不要被凍傷。

6. Carry out the maintenance and operation inside the chamber/condenser, please follow the relevant provisions concerning small spaces. There may be lack of oxygen inside of the chamber/condenser

進入或在干燥箱、冷阱上進行維護操作時，請遵照關于狹小空間的相關規定。在箱體或冷阱內部可能會出現缺氧。

7. Be aware of trapping your hands! Hands shall be kept away when the shelves are moving.

 注意夾手，當板層運動時，雙手請脫離板層組件。

8. Please keep your hands away when opening or closing the door or pizza door to avoid damage.

箱門或裝料門可能會夾手，當開關箱門或裝料門時，雙手請遠離運動區域。

9. When the lyophilization process is over, if it is needed to fill in the nitrogen gas, please ensure the chamber pressure is lower than ambient pressure. If the chamber inner pressure is positive and the chamber is without safety protection, it may cause damage. 

在凍干過程結束后，如果需要對箱體進行氮?dú)獗Ｗo(hù)或放氣用氮?dú)鈺r(shí)，請確保箱體內部壓力不能有正壓，箱體內部產生正壓是非常危險的，由于此時沒有進行安全保護，容易發生傷害事故，請不要誤操作。

10. When carrying out the leakage detection on refrigeration system, if it is needed, mix the refrigerant with nitrogen. prohibit the refrigerant blending with the compressed air to avoid flammable gas.

當對制冷系統進行泄漏檢測時，與氮?dú)饣旌鲜褂?。禁止與壓縮空氣混合使用，以防產生可燃性氣體。

11. Forbid using flammability liquid or gas inside or around the machine  because there is no explosion prevention design on the lyophilizer.

設備內部或周?chē)故褂每扇夹砸后w或氣體。本設備未進行防爆設計。

凍干機、產品凍干工藝、凍干生產線解決方案等問題歡迎咨詢劉經理13661495136

上海田楓冷凍干燥機廠家+解決方案提供商zuzu11.com